Rokon MOTORCYCLE Especificaciones Pagina 1

IllustratedOwners and Parts ManualROKON International Inc.50 Railroad AvenueRochester, NH 03839Tel: 603 335-3200Fax: 603 335-4400e-mail:[email protected]

When starting your ROKON, place the range selector in neutral.Stand on left hand side, put the front brake on with two fingers ofyour left hand, throt

Section 5 Continued Operating Your ROKON10The ROKON can be used to cross slow moving shallowwater of up to a maximum of 24 inches in depth. Beforeent

Routine care of your ROKON vehicle is easily done andis important for rider safety and vehicle longevity.1. Inspect all fasteners for tightness.2. The

Trouble ShootingSYMPTOM PROBABLE CAUSE1. Twist grip sticks.Twist grip end rubbing on handlebar.Deposit buildup under twist grip.Worn or broken twist g

Trouble ShootingSYMPTOM PROBABLE CAUSE5. Noisy driveline.Driveline improperly seated.Worn or broken override spring.Worn, broken or loose carrier bear

Trouble Shooting EngineSYMPTOM PROBABLE CAUSE1. Engine will not start. No fuel in tank or shut-off valve closed.Spark plug not firing.Fuel not being d

Trouble Shooting EngineSYMPTOM PROBABLE CAUSE6. Engine overheats. Engine overloaded.Oil too low in crankcase.Incorrect spark plug.Ignition timing over

Care and Adjustment of ROKON BrakesGeneral:Rokon all wheel drive vehicles have individual front and rear disc brakes. They are cable operatedby hand l

Section 6 Continued Periodic Maintenance and AdjustmentMaintenance:Cables are plastic lined and do not require lubrication though it is OK to do so.Be

I. TRANSMISSION AND DRIVELINE REMOVAL PROCEDURESection 1, Procedure for transmission removal:1. Elevate and secure the bike firmly to a non-moving st

Welcome to the growing group of ROKON owners. All operators must read and familiarizethemselves with this owners manual and the safety information.The

12. Remove all four transmission attaching bolts, three on the frame mount, and onenext to the upper cross shaft. (Two should already be removed from

II. Front Miter Box and Universal Joint Removal Procedure1. Remove front chain guard and front chain. Use a 1/2-inch wrench or socket toremove chain g

III. FRONT DRIVE LINE SYSTEMS CHECK1. Elevate bike so wheels are not touching the ground.2. Apply front brake.3. Rotate rear tire in forward direction

Torque and Threadlocking Specifications For Fasteners On Rokon 2WD VehiclesMiscellaneous SpecsTire Pressure 3 - 5 PSISee Engine Manual for engine deta

ROKON WARRANTY SYSTEMROKON International Inc. warranties to the original purchaser, new ROKON Utility vehicles to befree of defects that are the resul

Illustrated Parts ManualIndex of IllustrationsPage Nomenclature25 Brakes26 Chain Parts27 Decals28 Electrical29 Engine Honda30 & 31 Engine Kohler32

Item Part Number Name Description Qty1 108023 Live Side Housing 12 108024 Compression Spring 13 108025 Lever Arm 14 108026 Locking Nut 25 108027 Actua

Item Part Number Name Description Qty1 100356 Master Link 22 100355 Offset Link as needed3 100354 Full Link as needed4 108984 Chain Length as needed5

Item Part Number Name Qty1 108039 Decal "Trail-Breaker" in Black 22 101595 Decal "Scout" in Black 23 108041 Decal "Ranger&quo

Item Part Number Name Description Qty1 108177 Wiring Harness Front 12 108178 Wiring Harness Rear 13 104315 Rear Tail Light 14 104313 Headlight 15 1081

TABLE OF CONTENTSSECTION: Page1. Safety Information 3-42. Description and Machine Identification 53. Control Functions 6-74. Pre-Operation Checks 85.

Item Part Number Name Description Qty1 HONGX160 Honda Engine GX160 12 100369H Spark Plug 13 HON5247408 Air Filter 14 101548H Crank Key 15 108253 E Cli

Kohler EngineSection 10 Continued119183161714151347 695101211830ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A. Copyr

Item Part Number Name Description Qty1 KOH PA911512 6.6 Hp Kohler Command PS 12 KOH PA911513 6.6 Hp Kohler Command ES not shown 13 100369K Spark Plug

FrameSection 10 Continued2411023241126141539812613191817162122525732ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A. C

Item Part Number Name Description Qty1 105066 Frame 12 108243 Rear Fender Kohler 13 108994 Fairing LHS 14 108995 Fairing RHS Front 15 108996 Fairing R

Item Part Number Name Description Qty1 105064 Front Fork Weldment 12 100453 Front Fender 13 100935 Pop Rivet 54 103136 Snap Ring 15 100772 Bearing Sea

Item Part Number Name Description Qty1 100423 Front Cargo Rack 12 100167 Screw HH 1/4-20 x 1/2 23 100281 Washer 1/4" Lock Washer 24 100170 Screw

Item Part Number Name Description Qty1 103120-GR Fuel Tank Forest Green 12 102843 Fuel Cap 13 102766 Fuel Filter 14 101295 Shut off Valve 15 100122 Fu

Section 10 Continued37Item Part Number Name Description Qty1 108236 Muffler Kohler 12 108150 Muffler Honda not shown 13 108998 Sandwich Mount 24 10899

Section 10 Continued38Handle Bar124314314171817185610138101619 201515ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A.

Always wear an approved motorcycle helmet that fits properly, eye protection (gogglesor face shield), gloves, sturdy boots, long sleeve shirt, jacket

Section 10 Continued39Item Part Number Name Description Qty1 100466 Handlebar 12 100071 Grip Set 13 100820 Brake Lever 24 107036 Throttle Cable 15 100

Item Part Number Name Description Qty1 KOH6308619-S Screw, hex flange 32 KOH6316502-S Starter, retractable includes 3-9 13 KOH6308105-S Housing Assem

Item Part Number Name Description Qty1 100451H Front Seat 12 109002S Shock 13 108063 Seat Base Plate 14 108062 Lower Shock Mount 15 101629S Bolt Lag 5

Item Part Number Name Description Qty1 100340 Rear Seat 12 100343 Passenger Foot Peg Set 13 100281 Locking Washer Lock Washer 1/4 Spring 44 105037 Hex

Item Part Number Name Description Qty1 703209 Fixed Face and Hub Assy 12 601319 Moveable Face Assy 13 690144 Spring Kit not shown 14 690146 Roller Arm

Torque ConverterDriven PulleyItem Part Number Name Description Qty1 601311 Hub Fixed Face 12 703110 Bearing 13 703109 Movable Face 14 703111 Spring 15

Item Part Number Name Description Qty1 100349 Tow Bar 12 100007 Chain 13 103181 Rigid Tow Bar Accessory 14 100166 Bolt HH 1/4-28 x 1 15 100255 Washer

Fill LevelTransmissionComplete46Section 10 ContinuedROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A. Copyright 2004Fil

Item Part Number Name Description Qty1 101680 Transmission Assembly 12 100884 Rear Driven Clutch 13 100610 Brake Disc 14 100040 11 Tooth Sprocket 15 1

Transmission in Sequence48Section 10 Continued12364138373738372131123251120211210787894214175151618 19242526222726 51028 315 403032332934 35455566642R

Never exceed the stated load capacity. Cargo should be properly distributed and se-curely attached. Reduce speed and follow instructions in this manua

Transmissionin SequenceItem Part Number Name Description Qty1 101502 Transmission Casting Machined 2 halves 12 101523 Oil Seal 53 103142 Shaft Front O

Item Part Number Name Description Qty1 103131 Miter Box Assembly 12 100040 11 T Sprocket 13 108053 Miter Box Drive Shaft 14 103132 Miter Box Driven Sh

Item Part Number Name Description Qty1 101680 Transmission Case Assembly Three Speed 12 100039 Lock Washer 5/16 63 100038 Screw 5/16-18 x 7/8 54 10030

Item Part Number Name Description Qty1 100519 Tire 5.90 X 15 Goodyear Implement 22 100836 Tire 8 X 12 Titan 489 XT 23 100542 Valve Stem 12" only

Item Part Number Name Description Qty1 100519 Tire 5.90 X 15 Goodyear Implement 22 100836 Tire 8 x 12 Titan 489 XT 23 100541 Valve Stem 12" only

ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A. Copyright 2004Wiring DiagramSection 10 Continued54

Service/Maintenance LogDATE DESCRIPTION OF SERVICE55ROKON INTERNATIONAL, 50 Railroad Ave., Rochester, New Hampshire 03839, U.S.A. Copyright 2004

IMPORTANT – PLEASE COMPLY WITH THEFOLLOWING OWNER PREPARATION STEPS PRIORTO OPERATION OF YOUR NEW ROKON:1) READ AND BECOME THOROUGHLY FAMILIAR WITH TH

Record the Vehicle Identification number and Engine Number in the spaces below tofacilitate ordering spare parts or for reference if the vehicle is st

The Shut Off Switch is black in color and is located on the left hand side ofthe handlebar. Pressing the “kill” switch will shut off the engine. This

Recoil Starter. Firmly grasp the handle and pull slightly until engagement canbe felt. Then pull forcefully, being careful not to pull the rope all th

Before using this machine, check the following points.Front and Rear Brake. Check brake action. Check pucks to see that they are not overworn. There s